Air Cooled Chillers

 

 Home | About | Mri Chillers | Semi chiller solutions | Fermentation Solutions
General purpose and replacements | Order CDKey Catalog | Support

 

MRI Chiller

Semi chiller solutions

 

 

Semi Chiller Solutions

SEMI-HERMETIC PACKAGED AND SPLIT SYSTEM
AIR COOLED CHILLERS (1-90 Nominal Tons)

STANDARD FEATURES

  • Legacy microprocessor controller
  • Control transformer
  • Refrigerant suction accumulator
  • (1-12 HP) 316 STAINLESS STEEL (copper brazed) plate evaporator with ½” insulation and secured in a steel bracket
  • (15-120 HP) shell and tube chiller barrel
  • Water flow switch
  • Condenser fan and control circuit fusing
  • Semi-Hermetic compressor with crankcase heater
  • Compressor vibration eliminators & spring isolator kit
  • Compressor oil safety control
  • Compressor and condenser motor contractors
  • Direct drive condenser fan motor
  • Fan cycle control (+40 F)
  • Rust resistant, high CFM, aluminum condenser fan blade
  • Condenser(s): copper tube / aluminum fin
  • Condenser clean out ports
  • Liquid line drier, sight glass, solenoid, TEV
  • Replaceable core liquid line drier (15-120 HP)
  • Removable hinged access panels
  • Galvanized steel sheet metal cabinet & base frame
  • ½” insulation on all water and refrigerant suction lines
  • Complete refrigerant charge from factory
  • Computerized factory run test under load conditions

AVAILABLE OPTIONS

  • Compressor cylinder unloading 7.5 Hp & up
  • Compressor fusing
  • Fused disconnect
  • Flooded condenser with receiver and head pressure control (-20 F)
  • Flooded condenser with heated receiver and head pressure control (-20 F)
  • Factory installed heat tape freeze protection thermostatically controlled
  • Special piping for de-ionized and reverse osmosis water systems
  • Shell and tube chiller barrel (1-12 HP)
  • Fused STAINLESS STEEL system process pump
  • Dual system process pump with manual or auto changeover
  • Water flow meter
  • Phase monitor
  • Condenser heresite coating (coastal protection)
  • Copper condenser coil (coastal protection)
  • “Gold” finned condenser coil (coastal protection)
  • 4 year extended compressor warranty
  • Hot gas by-pass capacity control with solenoid valve & time delay relay
  • Factory assisted start-up

SPLIT SYSTEM / EVAPORATOR SECTION
SINGLE / DUAL CIRCUIT

STANDARD FEATURES

  • Legacy microprocessor controller
  • (1-12 HP) S.S. brazed plate evaporator – (Only available for Single Circuit Systems)
  • (15-120 HP) shell and tube chiller barrel
  • Water flow switch
  • Suction accumulator
  • Remote Condenser
  • Condenser fan and control circuit fusing
  • Condenser fan motor contactors
  • Semi-hermetic compressor with crankcase heater
  • Compressor vibration eliminators & spring isolator kit
  • Compressor motor contactor
  • Compressor oil safety control
  • 24V control transformer
  • Liquid line drier, sight glass, solenoid, TEV
  • Refrigerant discharge / liquid access valves
  • Galvanized steel base frame
  • ½” insulation on all water and refrigerant lines
  • Complete refrigerant charge from factory\
  • Factory run test under load conditions

TANK SECTION
(30 to 600 Gallon Capacity)

STANDARD FEATURES

  • STAINLESS STEEL storage tan
  • ½” tank and fluid piping insulation
  • Copper fluid piping
  • Tank vent and drain connections
  • Tank pressure relief valve
  • Fused evaporator fluid re-circulating STAINLESS STEEL pump
  • Fluid pump discharge ball valve and cleanable “Y” strainer
  • Control box with pump terminal block
  • Painted galvanized steel sheet metal cabinet
  • 24V L.E.D. process fluid thermometers

AVAILABLE OPTIONS

  • Fused STAINLESS STEEL process pump
  • Tank fluid sight glass
  • Tank liquid level indicator with dry contacts
  • STAINLESS STEEL piping for reverse osmosis or de-ionized water applications
  • STAINLESS STEEL sheet metal cabinet
  • 1” tank and piping insulation in lieu of ½”
  • Seal-tight electrical connections
     


 Home | About | Mri Chillers | Semi chiller solutions | Fermentation Solutions
General purpose and replacements | Order CDKey Catalog | Support

Questions or problems regarding this web site should be directed to support@aircooledchillers.com
Copyright © 2005. All rights reserved.